Other wheel or tire problem on the 2003 Ford Expedition
3 crashes 3 of the 33 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When other wheel or tire problem gets reported
Owners of the 2003 Ford Expedition report other wheel or tire problem at a median of 15,000 miles. A quarter of the reports come in before 5,000 miles and a quarter after 35,000 miles, from 21 reports that carried an odometer reading.
A part like this is normally expected to survive 60,000 miles. It is the 6th most-reported problem on this model year.
The mileage distribution
The reported range runs from 100 miles at the tenth percentile to 90,000 miles at the ninetieth, a spread of 89,528 miles across the middle 80% of reports.
When the reports scatter this far, the mileage is telling you about how these cars were driven more than about the part itself.
76% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 100 miles | 4,521 miles | 16,000 miles | 33,000 miles | 89,628 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 3 a crash is mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $200–$1,500 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 15 model years of this car. It shows up earliest on the 2011, at a median of 5,000 miles, and latest on the 1997 at 130,000 miles.
By volume the 1999 carries the most reports, with 159; the 2003 has 33. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
While traveling on smooth dry pavement, the right rear tire suddenly exploded. Both the inside and outside sidewalls were blown out. This was a new original equipment tire with less than 8000 miles on it. The car had just been serviced by the dealership within the last three weeks and all tires were properly inflated. Ph *nlm **dimsii ivoq entry posted after 12/12/02 cut over to artemis**769301
Continental contitrac tr - p265-70r-17 sidewall came completely apart and almost caused a tragedy. My family is not safe with these tires on my new expedition - found out continental had a recall in 2002 and wanted to let you know of another problem - ford would not replace my tires - only the one that could have killed my family. There is no damage to the tread - the tire just completely seperated in 2 pieces. I would like to send a picture if possible, and would give you the tires for testing.
On a number of occasions the ABS system has failed to perform as described by the manufacturer. Upon stopping when the ABS takes over my vehicle bucks and sends me bucking through intersections. According to the dealership where I purchased this is the way the ABS works. This vehicle also has very poor visibility, there are many large blind spots. *nlm
Also reported on the 2003 Ford Expedition
Misfire or rough idle
Other engine problem
Other electrical problem
Other body or interior problem
Fuel pump failure
Tire blowout or tread separation
How far this goes
Complaints are voluntary, so 33 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other wheel or tire problem happen on the 2003 Ford Expedition?
Across 21 owner reports that included an odometer reading, half were filed by 15,000 miles. A quarter were filed before 5,000 miles and a quarter after 35,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other wheel or tire problem on the 2003 Ford Expedition?
33 reports have been filed with NHTSA, about 12 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed