Other body or interior problem on the 2006 Ford Escape
1 crash 1 of the 40 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When other body or interior problem gets reported
Owners of the 2006 Ford Escape report other body or interior problem at a median of 125,000 miles. A quarter of the reports come in before 67,500 miles and a quarter after 157,500 miles, from 28 reports that carried an odometer reading.
A part like this is normally expected to survive 88,000 miles. It is the 4th most-reported problem on this model year.
The mileage distribution
The reported range runs from 400 miles at the tenth percentile to 162,500 miles at the ninetieth, a spread of 163,190 miles across the middle 80% of reports.
When the reports scatter this far, the mileage is telling you about how these cars were driven more than about the part itself.
18% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 410 miles | 66,750 miles | 125,000 miles | 156,750 miles | 163,600 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 1 a crash is mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $200–$2,000 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 23 model years of this car. It shows up earliest on the 2022, at a median of 10,000 miles, and latest on the 2006 at 125,000 miles.
By volume the 2020 carries the most reports, with 637; the 2006 has 40. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
2006 ford escape xlt AWD - vibration in steering wheel and can be felt in body at about 55-65 MPH. Into dealer 4x for attempted repairs. Consulted with factory. No idea what is causing it. Dealer stated some of the models on the lot had the same problem. This could be an engineering fault or an assembly fault - but ford is selling faulty vehicles- and not taking any serious attempt to rectify. Could potentially be a serious mechanical failure in the future. *jb
Dt*: the contact stated the vehicle grinds during start up if it sits for a couple of days. On 04-18-06 the vehicle began to sputter along with a delay in the accelerator pedal and the engine. The dealership admitted there were other vehicle's with the same year, make and model that has the problem. The dealer arranged an appointment for the vehicle to be inspected this week. Updated 5/16/2006 - the door ajar light illuminated intermittently. The dealer lubed the door and applied weatherstripping. *nm
Dt*: the contact stated after driving for 15 minutes at any speed on a normal road conditions the driver seat and the front passenger seats create a severe pain at lumbar back region. The contact expressed the two front seats were not ergonomic, as they were in all vehicles previously owned. Updated 9/15/2006 - *nm
Also reported on the 2006 Ford Escape
Other speed control problem
Other powertrain problem
Other engine problem
Strut, shock or spring failure
Other suspension problem
Other brake problem
How far this goes
Complaints are voluntary, so 40 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does other body or interior problem happen on the 2006 Ford Escape?
Across 28 owner reports that included an odometer reading, half were filed by 125,000 miles. A quarter were filed before 67,500 miles and a quarter after 157,500 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is other body or interior problem on the 2006 Ford Escape?
40 reports have been filed with NHTSA, about 2.8 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed