Airbag warning light or occupant sensor fault on the 2002 Chrysler Voyager
Only 6 reports for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When airbag warning light or occupant sensor fault gets reported
There are 20 reports of airbag warning light or occupant sensor fault on the 2002 Chrysler Voyager, 6 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 85,000 miles. It is the 1st most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 28,000 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $300–$1,600 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 3 model years of this car. It shows up earliest on the 2002, at a median of 30,000 miles, and latest on the 2003 at 185,000 miles.
By volume the 2002 is the worst of them, which makes this a problem of this specific year rather than of the model as a whole.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
The air bag light comes on and a bell chimes while driving. After a short interval the light will go off only to come back on later. The service department at chrysler in milford, pa said it can not be checked out unless it remains on to be checked for a computer read out. The service attendant informed me that the air bag would not discharge when the light is on and I should hope I am not in an accident during this moment. This puts the driver and the passenger at risk during the time the airbag is not working. A customer following me had the same problem and received the same answer. This is a safety problem and I would like you to investigate and find a possible solution. Thank you. *jb
Dt*: the contact stated the airbag light illuminated. The dealership was unable to determine the problem, but replaced the passenger side seatbelt in an attempt to repair. A week later, the airbag light illuminated again and the dealership was unable to determine a problem.
Airbag lit stays light al the time,was told it was a bad sensor,there was never a recall for it. You would think there would be since its a safety feature 'air bag light'. The check engine light stays lit too, that has been on since my car had a tuneup done was also told that was a bad sensor . The dealer should recall these features I've heard there was alot of the same problem other people were having too. *tr
Also reported on the 2002 Chrysler Voyager
Fuel leak or fuel odor
Control module (ECM/PCM/BCM) failure
Loss of braking
Other powertrain problem
Complete transmission failure
Seat belt or retractor failure
How far this goes
This page is kept out of search results because 20 reports is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 20 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does airbag warning light or occupant sensor fault happen on the 2002 Chrysler Voyager?
Across 6 owner reports that included an odometer reading, half were filed by 30,000 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is airbag warning light or occupant sensor fault on the 2002 Chrysler Voyager?
20 reports have been filed with NHTSA, about 0.4 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed