No-start or intermittent start failure on the 2006 Chrysler 300
1 crash 1 of the 18 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When no-start or intermittent start failure gets reported
Owners of the 2006 Chrysler 300 report no-start or intermittent start failure at a median of 150,000 miles. A quarter of the reports come in before 90,000 miles and a quarter after 195,000 miles, from 15 reports that carried an odometer reading.
A part like this is normally expected to survive 88,000 miles. It is the 13th most-reported problem on this model year.
The mileage distribution
The reported range runs from 85,000 miles at the tenth percentile to 240,000 miles at the ninetieth, a spread of 155,070 miles across the middle 80% of reports.
A spread this wide points at use rather than design. Towing, climate, service history and city mileage all move a failure like this, so the median is a weak guide to any individual car.
0% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 87,130 miles | 88,824 miles | 150,000 miles | 196,303 miles | 242,200 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 1 a crash is mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $200–$1,800 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 9 model years of this car. It shows up earliest on the 2013, at a median of 15,000 miles, and latest on the 2006 at 150,000 miles.
By volume the 2008 carries the most reports, with 101; the 2006 has 18. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
As I was driving my car shut-off and started back up on it's own when I was starting from a red light. Going up the next hill it did it after stopping at a stop sign. Over the next few days it would do this at different times and different speeds. At times it would not start back up on it's own I had to turn the key. Eventually, it starting shutting off at the garage I sent it to while being run on machines. It turned out to be a computer problem that required a new computer be put in. I am filing this incident because for the 2007 model of the same car there was a recall and free replacement of the computer. I have been told by an chrysler maintenance worker that the reason the 2007 was covered was that the sub-contractor for that year was participating with chrysler to pay for the recall or paying it themselves. However, the sub-contractor for the 2006 model was not. I believe chrysler is responsible for their end product and should pay for my new computer and installation. This work cost me over $2,100 for a problem that they knew about. My mechanic was told by one chrysler dealer that there just have not been enough 2006…
The car was filled up with fuel and no more than 2-5 miles from the gas station while driving the engine cut off with no warning while in traffic. Was able to restart the engine and continue on and within a mile it stalled out again in traffic. This time the car would not start. The car was pushed to the side of the road. The oil pressure light was also coming on so did not want to push the car and cause further damage. After 45 mins I restarted the car fine and was able to drive 1 mile before it stalled out at a stop sign. Again no warning and the car lost all power and you were unable to stop the car easily or turn the wheel since all power was lost. The oil pressure light did come on again but did not occur until after the car engine cut off and all power was lost. This time I checked the oil and the level was fine but I still added an extra quart of oil. Then within 5 mins I was able to start the car and drive it the rest of the way 1-2 miles to the dealership. Upon arriving at the dealership we checked the error coded. The dealership than changed the oil and did a full inspection and drive of the car and was unable to…
The car was filled up with fuel and no more than 2-5 miles from the gas station while driving the engine cut off with no warning while in traffic. Was able to restart the engine and continue on and within a mile it stalled out again in traffic. This time the car would not start. The car was pushed to the side of the road. The oil pressure light was also coming on so did not want to push the car and cause further damage. After 45 mins I restarted the car fine and was able to drive 1 mile before it stalled out at a stop sign. Again no warning and the car lost all power and you were unable to stop the car easily or turn the wheel since all power was lost. The oil pressure light did come on again but did not occur until after the car engine cut off and all power was lost. This time I checked the oil and the level was fine but I still added an extra quart of oil. Then within 5 mins I was able to start the car and drive it the rest of the way 1-2 miles to the dealership. Upon arriving at the dealership we checked the error coded. The dealership than changed the oil and did a full inspection and drive of the car and was unable to…
Also reported on the 2006 Chrysler 300
Other powertrain problem
Other engine problem
Airbag inflator rupture
Fuel tank, filler or EVAP failure
Other fuel system problem
Shifter, linkage or stuck-in-park failure
How far this goes
Complaints are voluntary, so 18 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does no-start or intermittent start failure happen on the 2006 Chrysler 300?
Across 15 owner reports that included an odometer reading, half were filed by 150,000 miles. A quarter were filed before 90,000 miles and a quarter after 195,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is no-start or intermittent start failure on the 2006 Chrysler 300?
18 reports have been filed with NHTSA, about 0.3 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed