Stalling while driving on the 2005 Chrysler 300
2 fires 2 of the 17 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When stalling while driving gets reported
Owners of the 2005 Chrysler 300 report stalling while driving at a median of 70,000 miles. A quarter of the reports come in before 65,000 miles and a quarter after 145,000 miles, from 15 reports that carried an odometer reading.
A part like this is normally expected to survive 75,000 miles. It is the 15th most-reported problem on this model year.
The mileage distribution
The reported range runs from 35,000 miles at the tenth percentile to 190,000 miles at the ninetieth, a spread of 158,490 miles across the middle 80% of reports.
When the reports scatter this far, the mileage is telling you about how these cars were driven more than about the part itself.
13% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 33,510 miles | 67,000 miles | 69,700 miles | 146,500 miles | 192,000 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 2 a fire is mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $300–$2,500 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
This mode is classified as critical, which means a failure can leave the car unable to stop, steer, or stay out of the way of traffic. It is weighted accordingly in the risk score.
The same failure on other years
The same failure is reported on 8 model years of this car. It shows up earliest on the 2013, at a median of 40,000 miles, and latest on the 2014 at 75,000 miles.
By volume the 2006 carries the most reports, with 37; the 2005 has 17. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
2006 chrysler 300c with 5.7 liter hemi engine, 1,500 miles on odometer. Stalls and will/or very difficult to re-start. Stalled while driving which nearly caused an accident. Car at dealer now in port huron, mi. Told by dealer that chrysler does not have fix for "computer problem" and that computer will be pulled from vehicle and sent to chrysler engineering for evaluation; not sure when car will be fixed. Definitely a safety concer. Stalls without warning with total loss of power, steering and brakes.
Vehicle just shuts off while driving with no indication or no reason...lose all steering and brakes. Able to wait a of couple minutes and vehicle will start up again but then will shut off while driving. *jb
Right after I fueled my chrysler 300c, the engine stalled a number of times. At a red light it felt like my car surged forward as I kept my foot on the brake. It did not start right away after I put it in neutral but turned over after several attempts. We brought it to our chrysler dealer where we bought the vehicle and was advised about the fuel tank and that it needed to be replaced costing upwards of $3,000. *tr
Also reported on the 2005 Chrysler 300
Other powertrain problem
Airbag inflator rupture
Other engine problem
Other electrical problem
Shifter, linkage or stuck-in-park failure
Fuel tank, filler or EVAP failure
How far this goes
Complaints are voluntary, so 17 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does stalling while driving happen on the 2005 Chrysler 300?
Across 15 owner reports that included an odometer reading, half were filed by 70,000 miles. A quarter were filed before 65,000 miles and a quarter after 145,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is stalling while driving on the 2005 Chrysler 300?
17 reports have been filed with NHTSA, about 0.3 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed