Tail light, brake light or signal failure on the 2003 BMW 325I
2 fires 2 of the 26 reports for this failure mention a crash, a fire, an injury or a death. Those are the owner's words on the complaint form, not a verified finding, and one report can mention more than one.
When tail light, brake light or signal failure gets reported
Owners of the 2003 BMW 325I report tail light, brake light or signal failure at a median of 115,000 miles. A quarter of the reports come in before 70,000 miles and a quarter after 125,000 miles, from 22 reports that carried an odometer reading.
A part like this is normally expected to survive 85,000 miles. It is the 2nd most-reported problem on this model year.
The mileage distribution
The reported range runs from 30,000 miles at the tenth percentile to 135,000 miles at the ninetieth, a spread of 105,201 miles across the middle 80% of reports.
When the reports scatter this far, the mileage is telling you about how these cars were driven more than about the part itself.
14% of the dated reports were filed under 36,000 miles.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| 30,799 miles | 72,250 miles | 112,616 miles | 125,000 miles | 136,000 miles |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Of these reports, 2 a fire is mentioned. Owners write their own complaints and the agency does not verify them, so read this as what the reports say happened rather than as a confirmed count.
Putting it right typically runs $100–$900 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
The same failure on other years
The same failure is reported on 5 model years of this car. It shows up earliest on the 2005, at a median of 55,000 miles, and latest on the 2001 at 175,000 miles.
By volume the 2002 carries the most reports, with 32; the 2003 has 26. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
The tail light assembly keeps failing. And I loose the tail lights. The first time this happened was in 2005 on the right hand side and now it happened on the left hand side. *tr
My dashboard panel showed a warning light indicating that the tail light was having an issue. I was told by a service center that the tail light assembly may get hot enough to melt the plastic in the housing and it will have to be replaced. Upon inspection I found that the wire harness had melted and the power supply wire for one of the lights had melted the plastic and the wire had come free. Once free, it arced to the connector pin on the bulb holder assembly and degraded that pin until the connection was lost. All plastic pieces in contact with the parts are melted and burned. I contacted the bmw service center and was told that this is not a recall issue and I was responsible for replacing these parts. Pictures are available of the parts. *tr
Right rear lighting system, to include turn signal and brake light, on my 2003 bmw 325i works intermittently. Bmw acknowledged defect in system in si b 63 03 06, dated february 2007 but to date has refused to initiate a recall to fix this safety defect. *tr
Also reported on the 2003 BMW 325I
Airbag inflator rupture
Other electrical problem
Other lighting problem
Other body or interior problem
Other powertrain problem
Headlight failure or clouding
How far this goes
Complaints are voluntary, so 26 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does tail light, brake light or signal failure happen on the 2003 BMW 325I?
Across 22 owner reports that included an odometer reading, half were filed by 115,000 miles. A quarter were filed before 70,000 miles and a quarter after 125,000 miles. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is tail light, brake light or signal failure on the 2003 BMW 325I?
26 reports have been filed with NHTSA, about 1.4 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed