Airbag inflator rupture on the 2008 Audi A3
Only 4 reports for this mode came with an odometer reading, which is too few for percentiles to mean anything. The page is here because someone linked to it; treat the figures as anecdotes, and see the full report for this year instead.
When airbag inflator rupture gets reported
There are 18 reports of airbag inflator rupture on the 2008 Audi A3, 4 with a mileage attached. That is too few to place the failure on the odometer with any confidence.
A part like this is normally expected to survive 80,000 miles. It is the 1st most-reported problem on this model year.
The whole distribution
| 10th | 25th | Median | 75th | 90th |
|---|---|---|---|---|
| — | — | 89,000 miles | — | — |
Read the 10th percentile as “one report in ten arrived this early”. Exact figures are shown in this table because it is the table of record; everywhere else on the site they are rounded to the precision the sample can carry.
What a percentile can and cannot tell you here
These five numbers describe the readings owners gave, in order. The median is the middle one: half the reports arrived below it. The 10th and 90th are the edges of the bulk of the distribution, and the distance between them is the part worth reading. A tight spread — say 70,000 to 95,000 miles — points at something that wears out on a schedule, and the schedule is knowable. A wide one, 20,000 to 190,000, points at a fault that hits some cars and never troubles others, which means the mileage on the listing in front of you tells you very little about your odds.
What these figures are not is a survival curve. Every reading here comes from a car whose owner filed a complaint, so the sample contains only failures: it cannot say what share of the fleet made it past 150,000 miles untouched, because those owners had nothing to report. Nor is the mileage the moment of failure — it is the odometer reading as recalled at the time of filing, which may be weeks later and is sometimes rounded to the nearest ten thousand by the person typing it.
Percentiles are shown at all only once 8 readings exist for the vehicle and mode. Below that the middle of a handful of numbers is noise wearing a decimal point, so the figures are withheld rather than dressed up.
What happens, and what it costs
Putting it right typically runs $0–$0 at an independent US shop. That range is an editorial estimate held in this site's failure-mode catalogue, not a figure from NHTSA, and it is a repair cost rather than a diagnosis cost.
This mode is classified as critical, which means a failure can leave the car unable to stop, steer, or stay out of the way of traffic. It is weighted accordingly in the risk score.
The same failure on other years
The same failure is reported on 7 model years of this car. It shows up earliest on the 2013, at a median of 40,000 miles, and latest on the 2006 at 120,000 miles.
By volume the 2006 carries the most reports, with 39; the 2008 has 18. A mode that appears across most years of a model is usually a design choice rather than a bad batch.
If one year stands out to the left, that is the year to avoid; if the whole line sits at a similar mileage, this is wear rather than a defect in one production run.
Tick median reported mileage Solid middle half of reports Faint 10th to 90th percentile Colour how bad the failure is when it happens
What owners wrote
Verbatim from NHTSA complaint narratives, trimmed for length. The mileage is the one the owner gave.
Takata air bag communication from audi indicates a recall is in progress but according to their website there are no replacement parts, or schedule date to make repairs to the car. They should make an arrangement for alternative transportation while sorting out the issue. This is ridiculous, and dangerous. Who wants to use a dangerous car?
Takata recall: I received the attached notice from audi of america, inc., dated april 2016, and stating that my vehicle contains a takata frontal airbag inflator that "could potentially rupture if the vehicle is involved in a crash where the frontal airbags are designed to deploy. In the event of an inflator rupture, metal fragments could pass through the airbag cushion material, which may result in serious injury or death to vehicle occupants." the notice states that replacement parts are not available. I recently serviced my car, and again the dealer informed me that replacement parts are not available. I called audi usa today and they said that takata has not made replacement parts available at this time and they have no timeline for supplying the parts. I am deeply concerned that a critical piece of safety equipment in my vehicle could itself cause me or my passengers "serious injury or death." I would appreciate it if someone would please advise when these replacement parts will be made available for this critical repair. Thank you. *tr
Takata recall I received notice in january of 2019 that my vehicle was having a second recall on the takata airbags. I immediately attempted to have the repair done at my local dealership; I could not get through. I then contacted audi corporate, who said they left the local dealershiop messages on my behalf; again no response. After calling multiple other dealerships in my state, one a little over an hour from me actually replied to my messages. It took until june to get this recall completed. Neither audi usa nor it's local dealers seem to care about performing a safety recall in a timely manner.
Also reported on the 2008 Audi A3
Other powertrain problem
Control module (ECM/PCM/BCM) failure
Other engine problem
Radiator or coolant leak
Control arm, ball joint or bushing failure
Other electrical problem
How far this goes
This page is kept out of search results because 18 reports is not enough to publish percentiles from. It stays reachable because somebody looking at this exact car would rather see the reports than be told there are none.
Complaints are voluntary, so 18 is a floor and not a count of affected cars. Mileages are typed in by owners and cluster on round numbers. And the mode itself is assigned by software reading the complaint text, which is reliable in bulk and fallible one report at a time.
Questions this page answers
At what mileage does airbag inflator rupture happen on the 2008 Audi A3?
Across 4 owner reports that included an odometer reading, half were filed by 90,000 miles. A quarter were filed before — and a quarter after —. These are the mileages owners reported when they complained, not a prediction for any individual car.
How common is airbag inflator rupture on the 2008 Audi A3?
18 reports have been filed with NHTSA, about 1.7 per 1,000 vehicles. Complaints are voluntary, so this is a floor rather than a count of affected cars.
What this is and is not. These are the mileages at which owners chose to complain to a federal agency, which is not the same as the mileage at which the part fails on every car. It skews toward failures that happened outside warranty, cost real money, or frightened someone. It is still the only public dataset that carries failure mileage at all, and the shape of a few hundred readings is informative even when a single one is not. Methodology · JSON · this failure on other cars
Source Owner complaints and recall records published by the US National Highway Traffic Safety Administration, model years 1996–2027 Figures rebuilt Published by AtWhatMileage How every figure is computed